|
|
|
Driving Vehicle into
Workshop
|
|
Instrument gauges,
warning/control lights and horn |
Check
operation |
|
Clutch |
Check operation/adjust, if
necessary |
|
Washers, wipers |
Check operation/adjust, if
necessary |
|
Inside Vehicle
|
|
Exterior and respective
control lights; instrument cluster illumination |
Check operation/condition |
|
Handbrake |
Check operation/adjust, if
necessary |
|
Seat belts, buckles and
stalks |
Check operation/condition |
|
Odour filter/ Odour filter
plus |
Renew - as specified |
|
Outside Vehicle
|
|
Hood latch/ safety catch &
hinges |
Check operation/grease |
|
Under Hood
|
|
Wiring, pipes, hoses, oil
and fuel feed lines |
Check for routing, damage,
chafing and leaks |
|
Engine, vacuum pump, heater
and radiator |
Check for damage and leaks
|
|
Coolant |
Check anti-freeze
concentration:__°C |
|
Coolant expansion tank,
washer reservoirs and battery |
Check/top up fluid levels as
necessary - in case of abnormal fluid loss, a separate order is required
to investigate and rectify |
|
Power steering fluid |
Check/top up fluid levels as
necessary - in case of abnormal fluid loss, a separate order is required
to investigate and rectify |
|
Battery terminals |
Clean, if necessary/grease |
|
Under Vehicle
|
|
Engine |
Drain oil and renew oil
filter |
|
Steering, suspension
linkages, ball joints, side shaft joints, gaiters |
Check for damage, wear,
security and rubber deterioration |
|
Engine, transmission |
Check for damage and leaks |
|
Pipes, hoses, wiring, oil
and fuel feed lines, exhaust |
Check for routing, damage,
chafing and leaks |
|
Underbody |
Check condition of PVC
coating |
|
Tyres |
Check wear and condition,
especially at tyre wall, note tread depth |
|
Brake system |
With wheels off, check brake
pads and discs for wear. Check rear brake linings for wear (using drum
brake inspection hole). (More often under severe duty conditions) |
|
Outside Vehicle
|
|
Engine |
Refill engine oil |
|
Tyres |
Adjust pressure |
|
Spare wheel |
Adjust pressure, check wear
- condition (note tread depth)__mm |
|
Luggage compartment lamp |
Check operation - if
applicable |
|
Wheel nuts |
Tighten to correct torque
and check for correct type. Check for rim damage |
|
Wheel covers |
Check for damages,
especially at retainer system |
|
Service reminder sticker |
Affix to driver side B
pillar |
|
Parts Renewal |
|
Spark plugs |
Replace |
|
Additional Maintenance
(at customer request) |
|
Braking system |
Drain and refill brake fluid |
|
Cooling system |
Check pressure cap. Drain
and refill coolant |
|
Cam belt |
Replace |
|
Valve clearances |
Adjust as required |
|
Fuel filter |
Replace |
|
Pollen / odour filter |
Replace |
|
Air conditioning |
Duct clean / diagnosis and
re-gas / system service |
